Optical diagnostic on HCII combustion characteristics for NH3-PODE3 dual fuel engine

doi:10.3969/j.issn.1674-8484.2022.03.012

Abstract

Abstract:

Ammonia and PODE_n are important alternative fuels for internal combustion engines to achieve the dual carbon target, and the dual fuel combustion mode is a generally recognized potential technology route for ammonia combustion. Focusing on the dual fuel combustion mode of ammonia ignited by PODE_n, the effects of different PODE₃ injection times, the different ammonia energy fractions on the in-cylinder combustion images, and the combustion characteristics in the ammonia-PODE₃ homogeneous charge induced ignition (HCII) mode were systematically investigated based on an optical engine and the high-speed photography system. The results showed that PODE₃ has good ignition characteristics; with the PODE₃ injection time being delayed from crank angle (CA) - 20° to - 5°, the flame image area, the flame brightness and the peak heat release rate are increasing while the peak in-cylinder pressure increases first and then decreases; At a fixed direct injection (DI) time of CA -10°, the phase of CA10 and CA50 are gradually retarded with the ammonia energy fractions increasing, while both of the peak pressure and the peak heat release rate in the cylinder increase first and then decrease, indicating that there is an optimal ammonia-PODE₃ energy ratio.

Key words: internal combustion engines, dual fuel, ammonia, polyoxymethylene dimethyl ethers(PODE_n), homogeneous charge induced ignition (HCII), optical diagnostic

CLC Number:

TK448.21

MAO Jianshu, MA Xiao, MA Yue, WANG Zhi, ZHANG Yixiao, SHUAI Shijin. Optical diagnostic on HCII combustion characteristics for NH₃-PODE₃ dual fuel engine[J]. Journal of Automotive Safety and Energy, 2022, 13(3): 509-516.

Figures/Tables 10

References 16

[1]	帅石金, 王志, 马骁, 等. 碳中和背景下内燃机低碳和零碳技术路径及关键技术[J]. 汽车安全与节能学报, 2021, 12(4): 417-439.
	SHUAI Shijin, WANG Zhi, MA Xiao, et al. Low carbon and zero carbon technology paths and key technologies of ICEs under the background of carbon neutrality[J]. Autom Safe Energ, 2021, 12(4): 417-439. (in Chinese)
[2]	Yapicioglu A, Dincer I. Performance assesment of hydrogen and ammonia combustion with various fuels for power generators[J]. Int’l Hydro Energ, 2018, 43(45): 21037-21048.
[3]	Reiter A J, Kong S-C. Combustion and emissions characteristics of compression-ignition engine using dual ammonia-diesel fuel[J]. Fuel, 2011, 90(1): 87-97. doi: 10.1016/j.fuel.2010.07.055 URL
[4]	郭朋彦, 申方, 王丽君, 等. 氨燃料发动机研究现状及发展趋势[J]. 车用发动机, 2016(3): 1-5+13.
	GUO Pengyan, SHEN Fang, WANG Lijun, et al. Research status and development trend of ammonia fuel engien[J]. Vehi Engine, 2016(3): 1-5+13. (in Chinese)
[5]	胡剑全, 谢珊, 吴一纯, 等. 低碳氨发动机的研究[J]. 可再生能源, 2014, 32(10): 1505-1509.
	HU Jianquan, XIE Shan, WU Yichun, et al. Study on low carbon ammonia engine[J]. Rene Energ Resour, 2014, 32(10): 1505-1509. (in Chinese)
[6]	Gray Jr Jt D E, Meckel Nt, Quillian Jr Rd. Ammonia fuel: Engine compatibility and combustion.[J]. SAE Trans, 1967: 785-807.
[7]	Reiter A J, Kong S C. Demonstration of compression-ignition engine combustion using ammonia in reducing greenhouse gas emissions[J]. Energ Fuels, 2008, 22(5): 2963-2971. doi: 10.1021/ef800140f URL
[8]	Niki Y, Yoo D H, Hirata K, et al. Effects of ammonia gas mixed into intake air on combustion and emissions characteristics in diesel engine[C]// ASME Inte Comb Engine Fall Tech Conf, Greenville, South Carolina, 2016.
[9]	Yousefi A, Guo H, Dev S, et al. Effects of ammonia energy fraction and diesel injection timing on combustion and emissions of an ammonia/diesel dual-fuel engine[J]. Fuel, 2022, 314: 122723. doi: 10.1016/j.fuel.2021.122723 URL
[10]	LIU Haoye, WANG Zhi, LI Yanfei, et al. Recent progress in the application in compression ignition engines and the synthesis technologies of polyoxymethylene dimethyl ethers[J]. Appl Energ, 2019, 233: 599-611. doi: 10.1016/j.apenergy.2018.10.064
[11]	REN Shuojin, WANG Zhi, LI Bowen, et al. Development of a reduced polyoxymethylene dimethyl ethers (PODEn) mechanism for engine applications[J]. Fuel, 2019, 238: 208-224. doi: 10.1016/j.fuel.2018.10.111
[12]	MA Yue, CUI Longxi, MA Xiao, et al. Optical study on spray combustion characteristics of PODE/diesel blends in different ambient conditions[J]. Fuel, 2020, 272. Doi: 10.1016/j.fuel.2020.117691. doi: 10.1016/j.fuel.2020.117691
[13]	TONG Laihui, WANG Hu, ZHENG Zunqing, et al. Experimental study of RCCI combustion and load extension in a compression ignition engine fueled with gasoline and PODE[J]. Fuel, 2016, 181: 878-886. doi: 10.1016/j.fuel.2016.05.037 URL
[14]	Burger J, Siegert M, Ströfer E, et al. Poly(oxymethylene) dimethyl ethers as components of tailored diesel fuel: Properties, synthesis and purification concepts[J]. Fuel, 2010, 89(11): 3315-3319. doi: 10.1016/j.fuel.2010.05.014 URL
[15]	SUN Wenyu, WANG Guoqing, LI Shuang, et al. Speciation and the laminar burning velocities of poly(oxymethylene) dimethyl ether 3 (POMDME3) flames: An experimental and modeling study[J]. Proceed Combust Instit, 2017, 36(1): 1269-1278.
[16]	Hayakawa A, Goto T, Mimoto R, et al. NO formation/reduction mechanisms of ammonia/air premixed flames at various equivalence ratios and pressures[J]. Mech Engi J, 2015, 2(1): 14-00402.

缸径	83.1 mm
行程	105 mm
连杆长度	210 mm
压缩比	15.8
活塞形式	平顶
可视区域直径	58 mm
发动机转速	1 200 r/min
进气早开角CA	24°
进气晚关角CA	50°
排气早开角CA	86°
排气晚关角CA	16°

缸径	83.1 mm
行程	105 mm
连杆长度	210 mm
压缩比	15.8
活塞形式	平顶
可视区域直径	58 mm
发动机转速	1 200 r/min
进气早开角CA	24°
进气晚关角CA	50°
排气早开角CA	86°
排气晚关角CA	16°

m (PODE₃) mg	m (NH₃) mg	α (PODE₃) (°)	A %	φ
6.3	0	-20, -15, -10, -5	0	0.054
6.3	4.9	-10	77	0.098
6.3	9.9	-20, -15, -10, -5	154	0.142
6.3	14.8	-10	231	0.188
6.3	19.8	-10	308	0.235

m (PODE₃) mg	m (NH₃) mg	α (PODE₃) (°)	A %	φ
6.3	0	-20, -15, -10, -5	0	0.054
6.3	4.9	-10	77	0.098
6.3	9.9	-20, -15, -10, -5	154	0.142
6.3	14.8	-10	231	0.188
6.3	19.8	-10	308	0.235

Optical diagnostic on HCII combustion characteristics for NH₃-PODE₃ dual fuel engine

RichHTML

PDF

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 10

References 16

Related Articles 11

Recommended Articles

Metrics

Comments

Journal information

Online journal

Author center

Review center

Contact us

[1]	LIU Shang, CAI Kaiyuan, LIU Wei, WANG Wei, ZHAO Ziqing, ZHANG Ridong, ZHANG Qihang, MA Xiao, WANG Zhi. Experimental study on different combustion modes of ammonia blended engines [J]. Journal of Automotive Safety and Energy, 2022, 13(1): 142-148.
[2]	WANG Zhihao, ZHANG Xinhua, WU Huimin, LIU Chaohui, WANG Zhaowen, HUANG Ronghua, LI Dinggen, WANG Zhi. Effect of microwave assisted ignition on CO₂ diluted methane combustion [J]. Journal of Automotive Safety and Energy, 2022, 13(1): 149-156.
[3]	ZHANG Zhiyong, GAO Dingwei, LAI Haipeng, ZHANG Bin, XING Huafeng. Optical diagnostics of charge stratification compression ignition in high compression ratio gasoline engine [J]. Journal of Automotive Safety and Energy, 2021, 12(3): 410-416.
[4]	REN Shuojin, ZHANG Ming, GUO Yong, YAN Yan, WANG Zhi, WANG Jianxin. Experimental and numerical investigation of effects of compression ratio on dual-fuel combustion at medium and high load [J]. Journal of Automotive Safety and Energy, 2020, 11(4): 518-528.
[5]	HE Ping, RUAN Haoda , MEI Jiahua , WANG Congyang , LI Zhaoyang. Cooling strategy of a dual fuel injector needle valve under micro pilot ignition condition [J]. Journal of Automotive Safety and Energy, 2020, 11(3): 406-412.
[6]	HAN Zhiyu, WU Zhenkuo, GAO Xiaojie . Development trend of internal combustion engines in the revolution of automotive powertrain [J]. Journal Of Automotive Safety And Energy, 2019, 10(2): 146-160.
[7]	TONG Dehui, REN Shuojin,LI Yunqiang, WANG Zhijian,. Experimental investigation of improving HCII combustion at medium and high load by reducing compression ratio [J]. Journal Of Automotive Safety And Energy, 2016, 07(04): 412-419.
[8]	LIU Haoye, WANG Zhi, WANG Jianxin. Effects of induced injection-timing on combustion and emission performances in homogeneous-charge-induced-ignition (HCII) combustion by using polyoxymethylene dimethyl ethers (PODEn) [J]. Journal Of Automotive Safety And Energy, 2016, 07(01): 94-99.
[9]	YANG Bo, WEI Xing, XI Chengxun, NING Xiaokang, ZENG Ke*. Modification and the control strategy of equivalent heating value substitution with pilot-ignited natural gas dual-fuel engine [J]. Journal Of Automotive Safety And Energy, 2014, 5(04): 407-412.
[10]	LIU Yongfeng, JIA Xiaoshe, PEI Pucheng, LU Yong. Numerical simulations and experiments of oxygen-enriched combustion in engine and using liquid oxygen to solidify carbon [J]. Journal of Automotive Safety and Energy, 2014, 5(01): 76-82.
[11]	YU Chao, WANG Jianxin, WANG Zhi, WANG Buyu. Combustion and emission characteristics of homogeneous charge induced ignition engines [J]. Journal of Automotive Safety and Energy, 2011, 2(3): 263-270.